King Of The Hammers 2009 - Off-Road Magazine

What's the ultimate desert race? For two years now, Hammerking Productions has brought a unique format to the desert that had never been tried before. Traditional desert racing winds its way down washes and through the whoops but avoids the creepy-crawly canyons. By contrast, traditional rock crawling stays in the canyons and drivers often spend an entire afternoon covering three miles or less.

King of the Hammers is unique in that it combines wide-open washes and whoops with tight, twisty canyons chock full of boulders and dry waterfalls. This year, Hammerking co-staffers Dave Cole and Jeff Knoll laid out an 82-mile course that included each and every Hammer trail, connecting them with wide-open sections. Want some trail names? Here they are: Claw Hammer, Wrecking Ball, Jack Hammer, Sledge Hammer, Fissure Trail, Sunbonnet Pass, Aftershock, and Outer Limits. Many non-competition trail rigs would have fits with any one of these trails. Running them all successfully in rapid-fire order would require a well-built rig and a fresh and thorough race prep. Prerunning the course was allowed, and GPS downloads were available.

Another unique feature of King of the Hammers was that it deliberately took place during the work week. This was to make sure that the competition did not get in the way of recreational trail riding on the weekend. After the competition on Friday, the King of the Hammers crew spent Saturday cleaning up and repairing the trails.

We had a twofold approach to covering the race: we wanted to see the rigs in a high-speed section that might be part of a traditional desert racing course, and then we wanted to see the racers again as they tested their mettle on one of the Hammers.

What kind of rig does well both in the whoops and on the Hammers? It won't be a traditional desert buggy or a Trophy Truck. Trophy Trucks and traditional desert racing buggies are way too wide and don't have enough ground clearance for the Hammers, to say nothing of the obvious: most of these vehicles lack of four-wheel drive. A King of the Hammers winner won't be a traditional trail rig, either. Most trail rigs have gobs of un-sprung weight and under-damped suspension. Instead, the winning rig would posses a combination of suspension sophistry, low weight, a low center of gravity, and a drivetrain capable of both haulin' and crawlin'. Last year, Shannon Campbell won in a solid-axle, rear-engine buggy. This year Shannon, the 2008 King, showed up in a fresh rig that sported independent front suspension. Would Shannon get a second crown?

We'll cut to the chase. Shannon roared off the line, only to become sidelined with a fried transmission. A rule change from last year mandated that only crew members could work on the vehicles, and that the vehicles could not receive outside assistance. After Shannon's tranny died, he got towed back into the main pit for a transmission change. The tow back to the main pit was considered outside assistance, and netted him a DQ. This left the door open for a successor to the throne. That successor was Alamo, California's Jason Scherer. Scherer finished 16 minutes ahead of runner-up Casey Currie. The two completed the 82-mile course in 4 hours 42 minutes and 4 hours 58 minutes, respectively.

While competitions are exciting to both watch and participate in, there's another benefit to competitions. Holding a competition in a given location serves to legitimize that place as a venue for an organized activity. The Johnson Valley OHV area, home of the Hammers, is being considered for annexation by the neighboring 29 Palms Marine Base. Running King of the Hammers shows the Marines the value of Johnson Valley to the off-road community. Hopefully, King of the Hammers will give the Marine Corps one more reason to look elsewhere for additional Marine Base land. Jason Scherer may have been crowned the 2009 King of the Hammers, but if K.O.H. helps keep Johnson Valley open, then the whole off-road community wins.

Our first photo location was at mile 20-a section that included sandy curves and a few rock chutes. It was a place that could have been a part of a traditional desert racing course. This tight spot would likely be bypassed during a traditional desert race, but Jason Scherer cruised right through without drama.
Our first photo location was at mile 20-a section that included sandy curves and a few roc
King of the Hammers requires a rig with both high- and low-speed capability. Bypass shocks, long a staple on traditional desert racing trucks and buggies, have begun to show up on K.O.H. rigs. The combination of a coilover and a bypass shock gives temperature and damping control that air shocks just can't touch.
King of the Hammers requires a rig with both high- and low-speed capability. Bypass shocks

Independent front suspension has been shunned in the crawling world from the beginning, but IFS reared its bump-absorbing head at King of the Hammers this year......
Independent front suspension has been shunned in the crawling world from the beginning, bu
......If factory IFS systems were built as stout as this one, many crawlers would have embraced control arms and CV axles a long time ago.
......If factory IFS systems were built as stout as this one, many crawlers would have emb

Meticulous fabrication, such as the TIG-welded, dimple-died control arms on Jason Scherer's winning buggy, is making its way further into the crawling world. We also saw numerous Ford 9-inch axles in both front and rear applications, prized for their low weight and high strength.
Meticulous fabrication, such as the TIG-welded, dimple-died control arms on Jason Scherer'
Carey Steiner knows how to go fast. She's an AMA women's motocross champion and a former desert racer in Class 7S. In recent years, she's turned her attention to rock crawling. This experience with a variety of off-road disciplines meant that Steiner's skills were tailor-made for King of the Hammers.
Carey Steiner knows how to go fast. She's an AMA women's motocross champion and a former d
Brad Lovell in the Amsoil buggy gets a little air under the tires on his way through this turn. He took fifth. The rigs were going as fast as possible, but the unfavorable ratio of sprung weight (the chassis) to un-sprung weight (the axles, wheels, and tires) meant that the rigs couldn't reach the same velocities through the high-speed rough as their traditional desert racing counterparts. Once in the rocks, the wisdom of big tires and bombproof axles was apparent.
Brad Lovell in the Amsoil buggy gets a little air under the tires on his way through this

Just as we'd seen at mile 20, Jason Scherer was the first one through. Jason's run up Sledge was far from trouble-free. After he got this far, he slid backward through the notch, off the ledge, and onto his side.
Just as we'd seen at mile 20, Jason Scherer was the first one through. Jason's run up Sled
Under the impression that spectators couldn't touch the rig to set it back on its wheels, Scherer's spotter got out and pulled some winch line while looking for an anchor point.
Under the impression that spectators couldn't touch the rig to set it back on its wheels,
Pete Sohren, a fellow competitor who was out of the race early, was under the impression that spectators were allowed to right the vehicle, but nothing else. Not wanting to risk a DQ, Scherer wanted to be sure of that before he said 'ok.' Sohren held Scherer's antenna upright while the driver radioed race headquarters for a rule clarification. Sohren was right: spectators were allowed to help get the rig back on its wheels.
Pete Sohren, a fellow competitor who was out of the race early, was under the impression t

About a dozen sets of hands sprang into action, and Scherer's rig was rubber-side down again.
About a dozen sets of hands sprang into action, and Scherer's rig was rubber-side down aga
He'd already burned up several minutes trying to drive through the obstacle, so Scherer wisely opted to winch through the notch. The rock in the foreground provided a perfect anchor point.
He'd already burned up several minutes trying to drive through the obstacle, so Scherer wi
The drama had just begun. Dust and tire smoke filled the air as drivers flung themselves at the ledge. The object of the race was to get to the finish line first, not to clean all the obstacles without using a winch. There was no penalty for winching, yet most drivers spent tons of time and wasted plenty of parts trying to drive up the ledge instead of winching after one or two unsuccessful tries. Still, you can't fault these guys for trying.
The drama had just begun. Dust and tire smoke filled the air as drivers flung themselves a

Casey Currie moseyed up in Shannon Campbell's '08 solid-axle rig. Casey's off-road experience includes dirt bikes, desert racing,.....
Casey Currie moseyed up in Shannon Campbell's '08 solid-axle rig. Casey's off-road experie
.....CORR Pro-lite racing, and being last year's runner-up in King of the Hammers. Casey approached the ledge, sized it up, and made it look easy. Casey took about 20 seconds where some took 20 minutes.....
.....CORR Pro-lite racing, and being last year's runner-up in King of the Hammers. Casey a
......Casey took second again in '09. If there's an heir-apparent for the King of the Hammers throne, it's Casey Currie.
......Casey took second again in '09. If there's an heir-apparent for the King of the Hamm

This shows 52X, Will Carter, after going shiny-side down at the notch. Carter was busy trying to right his buggy from the driver's seat. Unfortunately, spinning the wheels in both forward and reverse while sawing the steering wheel back and forth didn't work. Meanwhile, Shannon Campbell came up from behind. Remember the part about Campbell getting DQ'd? Since King of the Hammers was held on open trails in a public OHV area, the trails were technically open to drive on. Campbell, with his fresh tranny installed, was simply out for a drive.
This shows 52X, Will Carter, after going shiny-side down at the notch. Carter was busy try
Simply out for a drive" went out the window when Campbell reached Carter. Campbell used Carter's underside for traction on his way up the ledge and through the notch. The resulting contact burst Carter's front left shock, showering hydraulic oil all over the place.
Simply out for a drive" went out the window when Campbell reached Carter. Campbell used Ca
Famous or infamous? You decide.

Eric "Mustard Dog" Anderson was struggling with the ledge in his modified Formula Toyota chassis. Anderson ditched the leaf springs and four-cylinder engine for links and coilovers and throaty V-8 power. The V-8 and coilover infusion was helpful, but the ledge gave Anderson the smack down time and again. Meanwhile, Brian Shirley of Team Lucky Dog found his way up the ledge, only to have his steering system bleed out its fluid.
Eric "Mustard Dog" Anderson was struggling with the ledge in his modified Formula Toyota c